Kyle TX Heating & Air Conditioning Services

Performed a heater tune-up on a Rheem furnace system. Checked the electrical, mechanical and performance systems of the unit. Cleared, cleaned, flushed and treated the drain line and cleaned the exterior of the air handler. I did find that the upstairs filter is dirty so I removed it from the system to prevent any unwanted stress.

Removed existing filter dryer and metering device fitting from the outdoor unit. Installed new metering device fitting and section of 3/8 copper outside. Installed new bi-flow filter dryer in the attic space. Cleared drain with CO2 and primed trap with water. Pressure tested system with nitrogen and pulled a vacuum. Charged AC with R-410A refrigerant. Added new locking caps to the refrigerant ports on the condenser and sprayed JS-685 ant control inside the electrical panel. Tested operation of the system and existing zoning equipment. Everything is working at completion of service.

Installed 3 ton straight electric mobile home system. New pad and disconnect box installed for the condenser. Installed Honeywell T6 thermostat. Cleaned out the closet where the air handler sits. Cleared condensation drain with CO2 and tested with water. Pressure tested system with nitrogen and pulled vacuum. Tested heating and cooling operation of new system. Everything is working at completion of install.

Heat check completed on a vertical gas system. Flame sensor was cleaned. Drain line was flushed and treated. All mechanical and electrical components found within manufacturers specifications. No major issues were found. The system was running at completion of service.

Performed heat check. Checked the electrical, mechanical, safety, and performance of the system. I cleared the condensation drain line and flow tested the drain with two gallons of water. I also treated the drain line. The air filters were clean and had been recently replaced by the homeowner. No major issues were found. The system was running at the completion of service.

Performed heater tune-up on a Carrier heat pump system. Checked the electrical, mechanical and performance systems of the unit. Cleared, cleaned, flushed and treated the drain line and cleaned the exterior of the air handler. Filter was replaced with client supplied filter. All surge protection devices are working. System is operational at this time.

Performed heat check. Checked the electrical, mechanical, safety, and performance of the system. I cleared the condensation drain line and flow tested the drain with water. I also treated the drain line. The air filters were clean and had been recently replaced by the homeowner. No major issues were found. The system was running at the completion of service.

Removed failed inverter board. Installed new inverter board. Verified all wiring is tight. Function tested the system for 20 minutes with no issues. I did wash the outdoor coil and cleared the condensate drain line at no additional cost. The system is operational at this time.

Installed 4 ton Carrier heat pump system. Built and installed new supply plenum. Installed new plywood overlay for new air handler to sit on. Sealed all ductwork connections with mastic/hardcast. Cleaned out the return chase underneath the air handler. Rebuilt primary condensation drain, added safety switch to secondary. Cleared primary drain with CO2 and primed trap with water. Pressure tested system with nitrogen and pulled vacuum. Charge AC with R-454B refrigerant. Tested heating and cooling operation of new system. Everything is working at completion of install.

Heat check completed on a vertical heat pump system. Outdoor coils were cleaned. Drain line was flushed and treated. All mechanical and electrical components checked. I did find in rush amps to the compressor over what the manufacturer recommends. No other issues were found. The system is running at completion of service.

Heating tune-up completed on a vertical furnace. Flame sensor was cleaned. Air filter was changed. Drain line was cleared and treated. All electrical and mechanical components found within manufacturer specifications. No major issues were found. The system is heating properly at time of departure.

Performed heat check. Checked the electrical, mechanical, safety, and performance of the system. I cleared the condensation drain line and flow tested the drain with two gallons of water. I also treated the drain line. The air filter was clean and had been recently replaced by the homeowner. No major issues were found. The system was running at the completion of service.

Performed heat check. Checked the electrical, mechanical, safety, and performance of the system. I cleared the condensation drain line and flow tested the drain with two gallons of water. The air filter was clean and had been recently replaced by the homeowner. The blower wheel and air handler/evaporator coil are dirty. I went over what I had found with the homeowners. The system was running at the completion of service.

Performed heat check. Checked the electrical, mechanical, safety, and performance of the system. I cleared the condensation drain line and flow tested the drain with two gallons of water. I also treated the drain line. The air filter was clean and had been replaced by the homeowner before my arrival. Surge protectors on the system are operational. No major issues were found. The system was running at the completion of service.

Upstairs system: Installed Carrier straight electric system (upstairs system). Installed Ecobee pro thermostat. Replaced secondary drain pan. Installed new supply and return plenums. Installed AprilAire media cabinet. Rebuilt and insulated primary drain line. Installed SS2 and SS3 Safety switches. Removed triangle going to office. Upsized duct going into office and ran new duct for the bathroom. Installed a return in the office. Sealed all new ductwork connections with mastic/hardcast. Rebuilt and cleared primary drain with CO2 and primed trap with water. New condenser pad and disconnect box for the condenser. Pressure tested system with nitrogen and pulled vacuum. Extended drain line away from the house outside. Charged AC with R-454B refrigerant. Tested system operation. Everything is working at completion of install. Downstairs system: Installed vertical Carrier straight electric system in closet. Installed Ecobee pro thermos